Toyama TLM510TRMS-60L Lawn Mower Instruction Manual

1. Bubuka

This manual provides essential information for the safe operation, assembly, maintenance, and troubleshooting of your Toyama TLM510TRMS-60L self-propelled lawn mower. Please read this manual thoroughly before operating the machine to ensure proper use and to prevent injury or damage. Keep this manual in a safe place for future reference.

The Toyama TLM510TRMS-60L is a 6HP, 173cc, 51cm cut, 4-in-1 self-propelled lawn mower designed for efficient lawn care.

2. Parentah Kasalametan

PERHATOSAN: Failure to follow these safety instructions can result in serious injury or death. Always exercise extreme caution when operating power equipment.

2.1 Kasalametan Umum

• Read and understand all instructions in this manual before operating the lawn mower.
• Never allow children or untrained individuals to operate the machine.
• Anggo alat pelindung diri (APD) anu merenah, kalebet pelindung panon, pelindung pangrungu, sapatu anu kuat, sareng calana panjang.
• Inspect the area where the mower will be used and remove all objects that could be thrown by the blade (e.g., rocks, toys, wires).
• Ulah ngajalankeun mower lamun tataranjang suku atawa maké sendal muka.
• Jaga sadaya anu aya di sakitar, khususna barudak sareng piaraan, dina jarak anu aman ti daérah operasi.
• Never operate the mower under the influence of alcohol, drugs, or medication that could impair judgment.

2.2 Kasalametan suluh

• Fuel is highly flammable. Store fuel in approved containers in a cool, well-ventilated area.
• Never refuel the engine while it is running or hot. Allow the engine to cool down before refueling.
• Refuel outdoors in a well-ventilated area, away from sparks, open flames, or other ignition sources.
• Ulah ngaroko bari nanganan suluh.
• Langsung usap suluh nu tumpah.
• Replace the fuel cap securely after refueling.

2.3 Operasi Kasalametan

• Always check that the blade is securely fastened and in good condition before each use.
• Do not operate the mower in wet grass, as this can cause slipping and loss of control.
• Mow sakuliah beungeut lamping, pernah luhur jeung ka handap. Kudu ati-ati pisan nalika ngarobah arah dina lamping.
• Never pull the mower towards you while operating.
• Disengage the blade and stop the engine before crossing gravel drives, paths, or roads.
• Stop the engine and disconnect the spark plug wire before performing any adjustments, cleaning, or maintenance.
• Ulah ngangkat atawa mawa mower bari mesin jalan.

3. komponén Leuwihview

Familiarize yourself with the main components of your Toyama TLM510TRMS-60L lawn mower.

• Mesin: Provides power for the blade and self-propulsion.
• Stang: For steering and control, includes operator presence control and drive levers.
• Panyekel jukut: Ngumpulkeun potongan jukut.
• Dek motong: Imah sabeulah motong.
• Roda: For mobility, with height adjustment levers.
• Tangki BBM: For gasoline.
• Tutup Oli/Dipstick: For engine oil.
• Busi: For engine ignition.
• Filter hawa: Ngajagi mesin tina lebu sareng lebu.

4. Setélan

4.1 Majelis

Your lawn mower may require some assembly before first use. Follow these general steps:

1. Ngabongkar: Sacara saksama miceun sadaya komponén tina bungkusan.
2. Pamasangan Handlebar: Attach the lower and upper handlebars using the provided bolts and knobs. Ensure all cables are routed correctly and not pinched.
3. Majelis Penangkap Jukut: Assemble the grass catcher bag if it came disassembled, then attach it to the rear discharge opening.
4. Pariksa Fasteners: Ensure all nuts, bolts, and screws are securely tightened.

4.2 Cék Awal

• Tambahkeun oli mesin: Before starting for the first time, fill the engine with the recommended type and amount of engine oil. Refer to the engine manual for specific oil requirements. Do not overfill.
• Tambahkeun BBM: Fill the fuel tank with fresh, unleaded gasoline. Do not use E85 or other high-ethanol fuels.
• Pariksa Filter Udara: Pastikeun saringan hawa beresih sareng dipasang leres.
• Inspeksi sabeulah: Verify the blade is sharp, balanced, and securely attached.

5. Parentah Operasi

5.1 Mimitian Mesin

1. Pastikeun tangki bahan bakar pinuh sareng tingkat oli leres.
2. Move the throttle lever (if present) to the "FAST" or "START" position.
3. If the engine is cold, apply choke as per engine manufacturer's instructions.
4. Firmly grasp the operator presence control bar against the handle.
5. Pull the starter rope with a rapid, continuous motion until the engine starts.
6. Once the engine starts, slowly release the choke (if used) and allow the engine to warm up for a few moments.

5.2 Ngeureunkeun Mesin

To stop the engine, release the operator presence control bar. The engine and blade should stop within a few seconds.

5.3 Téhnik Mowing

• Ngepaskeun Jangkungna Penyesuaian: Adjust the cutting height using the levers on each wheel or a central lever (depending on model). For best results, avoid cutting more than one-third of the grass blade length at a time.
• Self-Propelled Drive: Engage the drive lever to activate the self-propulsion system. Adjust your walking speed to match the mower's pace.
• Pola: For an even cut, overlap each pass slightly. Mow in straight lines.
• Discharge Options (4-in-1):
  • Kantong: Attach the grass catcher to collect clippings.
  • Mulching: Install the mulching plug (if included) to finely chop and redistribute clippings back onto the lawn.
  • Discharge samping: Attach the side discharge chute (if included) to direct clippings away from the mower.
  • Discharge pungkur: Without the grass catcher or mulching plug, clippings are discharged from the rear.

6. Pangropéa

Regular maintenance is crucial for the longevity and safe operation of your lawn mower. Always stop the engine and disconnect the spark plug wire before performing any maintenance.

6.1 Sanggeus Unggal Pamakéan

• Ngabersihan dek: Remove grass clippings and debris from the underside of the cutting deck.
• Empty Grass Catcher: Empty and clean the grass catcher.
• mariksa: Check for loose fasteners, damaged parts, or excessive wear.

6.2 Oli Mesin

• Pariksa Level Oli: Pariksa tingkat minyak saméméh unggal pamakéan.
• Ganti oli: Change the engine oil after the first 5 hours of operation, then every 25-50 hours or annually, whichever comes first. Refer to the engine manual for specific intervals and oil type.

6.3 Filter hawa

• Bersih / Ganti: Inspect the air filter regularly. Clean or replace it more frequently in dusty conditions.

6.4 Busi

• Inspect/Clean/Replace: Inspect the spark plug annually. Clean off carbon deposits or replace if worn. Ensure correct gap.

6.5 motong sabeulah

• Sharpen/Replace: Inspect the blade regularly for sharpness and damage. Sharpen or replace as needed. A dull blade tears grass, leading to an unhealthy lawn.
• Kasaimbangan: Pastikeun bilahna saimbang saatos diasah pikeun nyegah geteran anu kaleuleuwihi.

7. Cara ngungkulan

This section addresses common issues you might encounter. For problems not listed here, contact an authorized service center.

8. Spésifikasi

9. Garansi jeung Rojongan

For warranty information, please refer to the warranty card included with your product or visit the official Toyama websitus. Simpen bukti pameseran anjeun pikeun klaim garansi.

For technical support, spare parts, or service, please contact an authorized Toyama service center. Contact details can typically be found on the Toyama websitus atanapi dina dokuméntasi produk Anjeun.